Suzuki GSX-R 1000 Owners Manual: Clutch adjustment
Clutch cable play should be 1 0 - 15 mm (0.4 - 0.6 In) measured at the clutch lever end. Adjust clutch cable play according to the following procedure:
Minor adjustment
Turn the clutch cable adjuster 1 to provide the specified play.
Major adjustment
- Turn in the adjuster 1 all the way.
- Remove the cap from the right side engine cover.
- Hold the clutch push piece 2 and loosen the lock nut 3.
- Hold the clutch push piece 2 And turn in the adjuster 4 until it stops. Hold the clutch push piece 2 And turn out the adjuster 1/2 turns.
- Hold the clutch push piece 2 And tighten the lock nut 3.
- Adjust the clutch cable play with the adjuster 1.
Fuel hoses
Inspect the fuel hoses for damage
and fuel leakage. If any defects
are found, the fuel hoses must be
replaced. ...
Engine coolant
Coolant level
The engine coolant solution
should be between "f" (full) and
"1..:' (Low) level lines on the engine
coolant reservoir. If the level is
lower than "1..:' (Low ...
Other materials:
Rear brake pedal construction
Footrest bracket no. 2
Footrest bracket no. 1
Rear brake peda
Footrest holder
Footrest
35 N·m (3.5 Kgf-m,
25.5 Lbf-ft)
23 N·m
(2.3 Kgf-m, 16.5 Lbf-ft)
18 N·m
(1.8 Kgf-m, 13.0 Lbf-ft)
Apply grease.
Apply thread lock to the ...
Air cleaner box removal and installation
Removal
Lift and support the fuel tank. Refer to “fuel tank
removal and installation” in section 1g (page 1g-
9).
Remove the air cleaner box cover. Refer to “air cleaner element removal
and installation” .
Remove the air cleaner mounting bolt.
Remove the air clea ...
Spark plug inspection and cleaning
Inspect spark plug
every 6 000 km (4 000 miles, 12 months)
Heat range
Remove the spark plugs. Refer to “ignition coil and spark plug removal
and installation” in section 1h .
Check spark plug heat range by observing electrode
color. If the electrode of the spark plug is wet
appe ...