Suzuki GSX-R 1000 Service Manual: Diagnostic information and procedures
- Engine symptom diagnosis
- Self-diagnostic procedures
- Use of sds diagnosis reset procedures
- Show data when trouble (displaying data at the time of DTC)
- Sds check
- DTC table
- Fail-safe function table
- Fi system troubleshooting
- Malfunction code and defective condition table
- DTC “c11” (p0340): cmp sensor circuit malfunction
- DTC “c12” (p0335): ckp sensor circuit malfunction.
- DTC “c13” (p0105-h/l): iap sensor circuit malfunction
- DTC “c14” (p0120-h/l): tp sensor circuit malfunction
- DTC “c15” (p0115-h/l): ect sensor circuit malfunction
- DTC “c21” (p0110-h/l): iat sensor circuit malfunction
- DTC “c22” (p1450-h/l): ap sensor circuit malfunction
- DTC “c23” (p1651-h/l): to sensor circuit malfunction
- DTC “c28” (p1655): secondary throttle valve actuator (stva) malfunction
- DTC “c29” (p1654-h/l): secondary throttle position sensor (stps) circuit malfunction
- DTC “c31” (p0705): gp switch circuit malfunction
- Dtc “c32” (p0201), “c33” (p0202), “c34” (p0203) or “c35” (p0204): primary fuel injector circuit malfunction
- Dtc “c36” (p1764), “c37” (p1765), “c38” (p1766) or “c39” (p1767): secondary fuel injector circuit malfunction
- DTC “c40” (p0505 / p0506 / p0507): isc valve circuit malfunction
- DTC “c41” (p0230-h/l): fp relay circuit malfunction
- DTC “c41” (p2505): ecm power input signal malfunction
- DTC “c42” (p1650): ig switch circuit malfunction
- DTC “c44” (p0130/p0135): ho2 sensor (ho2s) circuit malfunction
- DTC “c46” (p1657-h/l or p1658): excv actuator circuit malfunction
- DTC “c49” (p1656): pair control solenoid valve circuit malfunction
- DTC “c60” (p0480): cooling fan relay circuit malfunction
- DTC “c62” (p0443): evap system purge control solenoid valve circuit malfunction (e-33 only)
- DTC “c91” (p0500): vehicle speed sensor circuit malfunction
- DTC “c93” (p1769): steering damper solenoid valve circuit malfunction
Component location
Fi system parts location
...
Other materials:
Regulator / rectifier construction
Regulator/rectifier
Regulator/rectifier bracket
Air intake pipe (rh)
Spacer
Wiring harness
Connect
the regulator/rectifier couplers under the wiring harness
10
N·m (1.0 Kgf-m, 7.0 Lbf-ft)
...
DTC “c12” (p0335): ckp sensor circuit
malfunction.
Detected condition and possible cause
Detected condition
Possible cause
The signal does not reach ecm for 3 sec. Or more, after
receiving the starter signal.
Metal particles or foreign material being stuck on the
ckp sensor and rotor tip.
Ckp ...
Special tools and equipment
Recommended service material
Note
required service material is also described in the following.
“Rear suspension components” “rear suspension assembly
construction”
Special tool
...