Suzuki GSX-R 1000 Service Manual: Rear brake hose routing diagram

Suzuki GSX-R 1000 Service Manual / Brake / Brake control system and diagnosis / Schematic and routing diagram / Rear brake hose routing diagram

Suzuki GSX-R. Rear brake hose routing diagram

Hose clamp
: face the clamp end backward.
Stopper
: after the brake hose union has contacted to the stopper, tighten the union bolt.
Brake pad pin
Plug
Caliper sliding pin b
Caliper sliding pin a
White marking
Yellow marking
Pass the
reservoir hose above the brake hose
23 N·m (2.3 Kgf-m,
16.5 Lbf-ft)
10 N·m
(1.0 Kgf-m, 7.0 Lbf-ft)
27 N·m
(2.7 Kgf-m, 19.5 Lbf-ft)
12 N·m
(1.2 Kgf-m, 8.5 Lbf-ft)
17 N·m
(1.7 Kgf-m, 12.5 Lbf-ft)
2.5 N·m
(0.25 Kgf-m, 2.0 Lbf-ft)
6 N·m
(0.6 Kgf-m, 4.5 Lbf-ft)

Front brake hose routing diagram

Hose clamp : clamp end should face downward. Stopper : after the brake hose union has contacted to the stopper, tighten the union bolt. Hose guide : pass t ...

Diagnostic information and procedures

Brake symptom diagnosis ...

Other materials:

DTC “c91” (p0500): vehicle speed sensor circuit malfunction
Detected condition and possible cause Detected condition Possible cause Speedometer does not receive signal from the vehicle speed sensor for more than 6 sec. When the motorcycle is running. Ecm does not receive signal from the vehicle speed sensor for more than ...

DTC “c15” (p0115-h/l): ect sensor circuit malfunction
Detected condition and possible cause Detected condition Possible cause C15 Output voltage is not with in the following range. 0.15 V ≤ Sensor voltage < 4.85 V Ect sensor circuit open or short. Ect sensor malfunction. Ec ...

Fuel line inspection
Inspect fuel line every 6 000 km (4 000 miles, 12 months) Inspect the fuel line in the following procedures: lift and support the fuel tank. Refer to “fuel tank removal and installation” in section 1g (page 1g- 9). Inspect the fuel feed hose (1) for damage and fuel leakage. ...