Toyota RAV4 manuals

Suzuki GSX-R 1000 Service Manual: Reflex reflector construction

Suzuki GSX-R. Reflex reflector construction


  1. Front reflex reflector x 2 pcs. (For e-03, 24, 28, 33)
  2. Rear reflex reflector x 2 pcs. (For e-03, 28, 33)
  3. 1.8
    Nm (0.18 Kgf-m, 1.5 Lbf-ft)
Rear turn signal light bulb replacement
Caution when you touch the bulb with your bare hands, clean the bulb with a cloth moistened with alcohol or soap water to prevent premature bulb failure. Remove the rear tu ...

Turn signal / side-stand relay inspection
Refer to electrical components location in section 0a . Note make sure that the battery is fully charged. Before removing the turn signal/side-stand relay, check the operation of t ...

Other materials:

Rear wheel removal
Place the motorcycle on the side stand. Remove the cotter pin 1.  Remove the axle nut 2. Warning A hot muffler can burn you. The muffler will be hot enough to burn you for some time after stopping the engine. Wait until the muffler cools to avoid bur ...

Water pump construction
Impeller Mechanical seal Oil seal O-ring O-ring 8 Nm (0.8 Kgf-m, 6.0 Lbf-ft) 10 Nm (1.0 Kgf-m, 7.0 Lbf-ft) Apply grease. Apply engine coolant. Apply molybdenum oil solution. Do not reuse. ...

Gearshift shaft / gearshift cam plate components
Gearshift shaft Gearshift cam drive plate Gearshift cam plate Gearshift cam stopper 19 Nm (1.9 Kgf-m, 13.5 Lbf-ft) 13 Nm (1.3 Kgf-m, 9.5 Lbf-ft) 8.5 Nm (0.85 Kgf-m, 6.0 Lbf-ft) Apply grease to oil seal lip. Apply thread l ...

2011-2022 Copyright www.suzukigsxr.org