Suzuki GSX-R 1000 Owners Manual: Throtile cable play
This motorcycle has a twin throttle cable system. Cable A is for pulling cable and cable B is for returning.
To adjust the cable play:
- Loosen the lock nut 1.
- Turn the adjuster 2 so that the throttle grip has 2.0 - 4.0 Mm (0.08- 0.16 In) play.Tighten the lock nut 1.
 Warning
Adjust the throttle cable play so that engine idle speed does not rise due to handlebars movement. |
Idle speed
Adjust the engine idle speed periodically on the engine at normal operating
temperature.
To adjust the idle speed:
Lift the fuel tank by referring to
the air cleaner section.
St ...
Fuel hoses
Inspect the fuel hoses for damage
and fuel leakage. If any defects
are found, the fuel hoses must be
replaced. ...
Other materials:
DTC “c91” (p0500): vehicle speed sensor
circuit malfunction
Detected condition and possible cause
Detected condition
Possible cause
Speedometer does not receive signal from the vehicle
speed sensor for more than 6 sec. When the motorcycle is
running. Ecm does not receive signal from the vehicle
speed sensor for more than ...
Crankcase emission control system
description
The engine is equipped with a pcv system to prevent discharging crankcase
emissions into the atmosphere. Blow-by
gas in the engine is constantly drawn into the crankcase, which is returned to
the combustion chamber through the
pcv (breather) hose, air cleaner and throttle body.
...
Cooling fan relay inspection
Inspect the fan relay in the following procedures:
remove the frame covers. Refer to “exterior parts
removal and installation” in section 9d (page 9d-
6).
Remove the cooling fan relay (1).
First check the insulation between “a” and “b”
terminals with tester. Then ap ...