Suzuki GSX-R 1000 Service Manual: Voltage check
If voltage is supplied to the circuit being checked, voltage check can be used as circuit check.
- With all connectors/couplers connected and voltage applied to the circuit being checked, measure voltage between each terminal and body ground.
- If measurements were taken as shown in the figure and results were listed in the following, it means that the circuit is open between terminals “a” and “b”.
Voltage between
“a” and body ground: approx. 5 V
“b” and body ground: approx. 5 V
“c” and body ground: 0 V
- Also, if measured values are as listed following, a resistance (abnormality) exists which causes the voltage drop in the circuit between terminals “a” and “b”.
Voltage between
“a” and body ground: approx. 5 V
“b” and body ground: approx. 5 V – 2 v voltage
drop
“c” and body ground: 3 v – 2 v voltage drop
Continuity check
Measure resistance across coupler “b” (between “a”
and “c” in figure).
If no continuity is indicated (infinity or over limit), the
circuit is open between terminals “a” and “c”.
Dis ...
Short circuit check (wire harness to ground)
Disconnect the negative (–) cable from the battery.
Disconnect the connectors/couplers at both ends of
the circuit to be checked.
Note
if the circuit to be checked branches t ...
Other materials:
Headlight beam adjustment
Adjust the headlight beam, both horizontally and
vertically.
Note
to adjust the headlight beam, adjust the
beam horizontally first, then vertically.
It is not necessary to remove the
combination meter to turn the adjusters.
Horiz ...
Rear brake master cylinder parts inspection
Refer to “rear brake master cylinder disassembly and assembly” .
Master cylinder
Inspect the master cylinder bore for any scratches or
other damage.
Piston / rubber parts
Inspect the piston surface for any scratches or other
damage.
Inspect the primary cup, secondary cup and dust boot
...
Emission control warranty
Suzuki motor corporation warrants
to the ultimate purchaser
and each subsequent purchaser
that this vehicle is designed, built,
and equipped so as to conform at
the time of sale with all U.S. Emission
standards applicable at the
time of manufacture, and that it is
free from defects in materi ...